Brown’s RV • Comprehensive Pre-Trip Packages

• Test house battery voltage (fully charged should read ~12.7 volts)
• Clean and insect battery terminals for corrosion
• Verify shore power connection and test pedestal polarity (using a polarity tester)
• Test onboard inverter/charger or converter operation
• Ensure generator starts, runs under load and powers all systems
• Inspect extension cords and surge protectors for damage
• Confirm all lights are operational (interior, porch, marker, brake, turn)
• Reset or test circuit breakers and GFCI outlets
• Replace any blown fuses in DC fuse panel

• Clean and replace AC air filters
• Inspect evaporator and condenser coils for dust buildup
• Test thermostat settings and cooling performance
• Check rooftop AC shroud for cracks or missing screws
• Verify roof vents and fans operate properly and seals are intact
• Ensure all ductwork vents are open and clear of debris

• Perform leak check (using a manometer or soapy water on connections)
• Confirm LP tank level is filled
• Inspect pigtail hoses and regulators for cracks or corrosion
• Confirm propane detector is operational and not expired
• Light and test each propane appliance (stove, fridge, furnace, water heater)

• Sanitize freshwater tank with diluted bleach solutions (especially after storage)
• Run water pump and inspect for pressure and leaks
• Test faucets, shower head, toilet, and outdoor spigots for leaks or clogs
• Check water heater operation on both propane and electric modes
• Verify water heater pressure relief valve is not struck or leaking
• Inspect water hoses for cracks, kinks, or leaks
• Use a water pressure regulator on city water connection
• Empty and flush black and gray tanks; verify tank sensors are working
• Inspect sewer hose and fittings for cracks or loose seals

• Check tire pressure (when cold) for all tires, including the spare
• Inspect tread depth and look for uneven wear
• Look for sidewall cracks, bulges, or dry rot
• Verify tire age (replace if older than 5-7 years)
• Torque lug nuts to spec
• Inspect suspension, leaf springs, and shocks for damage or rust
• Check undercarriage for loose wires or hanging components

• Inspect all roof seams and reapply sealant where cracks are present*
• Check skylights, roof vents, and AC units for secure mounting and leaks
• Clean and inspect slide out seals and mechanisms
• Check all window, door, and compartment seals
• Open and inspect awnings for mold rips, or damaged arms
• Wash and wax the RV exterior to protect against UV damage
• Inspect sidewalls for bubbling, delamination, or punctures

*includes up to two tubes of lap seal

• Test all appliances (microwave, fridge, range, etc.)
• Clean air intake grills and vents
• Check for signs of rodent or insect activity
• Test all smoke detectors, carbon monoxide detectors and LP gas alarms
• Replace batteries in all safety devices
• Verify the extinguisher is charged and accessible
• Check that drawers, cabinets, and doors latch properly
• Test interior lights, outlets, fans, and charging ports

• Inspect hitch and coupler for cracks, rust, or wear
• Verify safety chains are correctly crossed and latched
• Check electric brake controller and trailer brake function
• Test trailer breakaway switch and battery
• Check rv-to-tow vehicle wiring and test all trailer lights
• Confirm weight distribution and sway control hitches are adjusted
• Check dinghy lowing gear ( if towing a vehicle) for wear and attachment